You should have this done by a technician so you have a warranty with the job. To decide if your belt needs replacing, simply look at the grooved side of the belt to see if it is cracking badly. There are no clips to help hold the wires away from the metal. It won't come out unless the passenger side engine mount is unbolted 3 bolts, 19 mm I think and the engine is pried forwards. It's a fairly common problem, so I'm posting the symptoms, codes and instructions here to help others.
There is some form of protection on the wires, I describe it as a foam. Apr 07, 2010 Instead of removing the engine mount, just slide the fan housing holds the two electric fans out of the way. If not,then you need a diagnostic chart,usually an emissions manual,to find the problems. The alternator is removed from underneath the vehicle. Reach in to the back of the headlight assembly and remove the black rubber boot… 2006 Ford Focus headlight bulb lamp replacement: Purchase the correct replacement headlight bulb s first, before disassembling the vehicle. This location places the alternator very near the exhaust piping and even though there is protective cooling vents, alternators fail as early as 70,000 miles.
As a consequence to this, my car is now just sitting, and I will not drive it with it being labeled a fire hazard. Upon installing the first one, you run several on car tests, to confirm it works properly. A stop at AutoZone might help. This allows plenty of clearance to remove the alternator and replace it. On the drivers side, remove the 3 Hex screws that hold the cruse control module.
However, before you replace yours, check the continuity through the electrical plug connection at the alternator. Open car hood and insert hood support. You also need a belt tensioner tool to get the belt off first. Our alternators also improve the reliability of your vehicle's performance so that you'll get more life out of your battery. This is a weak point of the Focus and can cause the alternator to not charge the battery properly. Once this was done, it would be pretty easy. The symptoms are that the '''transmission disengages slips out of gear when it goes into 3rd… Buy a good manual that covers the year of your Focus, read and understand it before you ever start.
Each time dealership told me that my alternator had gone bad. If the battery voltage is less than 12. First you test,the one, on the vehicle or remove,the first one and have the auto part store check it out. As simple as it sounds, the owner's manual is the best place to start for bulb replacement instructions and illustrations. Should be more than 12. Don't forget to remove the negative battery terminal before starting. If the voltage is less than 14 Volts with running engine, then the alternator is not working properly.
The hardest part is once the alternator has been disconnected from all its mechanical and electrical connections. They are very dependable and usually easy to replace. Shops are reporting Ford Focus Alternator Problems due to excessive resistance in the ground circuit. Perform a voltage drop test Perform these tests with the engine running. I changed out the… Ford Focus AlternatorMine was out of warranty and I had to have the alternator replaced.
What your doing lacks common sense. This is a repair the requires partial disassembly of the majority of your front suspension, in order to remove the axle. I just replace the alternator on our 2001 Focus with 70K on the odometer. If you do it wrong, you'll have a lot more work to do than if…. Our premium selection of Focus performance alternators generate more electrical current to power all of your vehicle's accessories and improve performance when you're driving on the road.
A couple of cracks every 3 inches is normal, but if you see cracks every 1-2 inches I would recommend that you replace it. Once this was done, it would be pretty easy. Flicked the headlight cover off using the screwdriver for a bit of leverage. Behind the steering reservoir there is… Hello. There is also an adjuster on the alt.
If you have specific questions after doing that, then research those question here, and on Focus forums on the internet. Sep 07, 2010 Why ,I have to ask,would you replace several alternators on a vehicle. Without a high-quality Ford Focus alternator, all of your vehicle's electrical functions diminish and your ability to enjoy many of its functions disappears. This allows plenty of clearance to remove the alternator and replace it. It is a tedious job but it can be done by loostening and removeing the bolts that hold the alternator on. Took it to Ford, was told there was nothing they could do because my powertrain warranty does not cover electrical work.
. They scan codes, and check alternators for free. The voltage should read at least 13 volts. You have to remove two one bolt out of the coolant overfill container pull itup a little and out of its retaining bracket. Took it to an electrician, was told a few wires touched metal and fused together and burnt all the way back to the firewall.